Tailgate lock (Hatchback and Estate models) - removal and refitting

Removal
1 Open the tailgate and prise out the trim panel using a wide-bladed screwdriver (see illustration).

12.1 Tailgate trim panel fixings - Hatchback and Estate models
12.1 Tailgate trim panel fixings - Hatchback and Estate models

2 Remove the lock barrel retaining clip, and where applicable disconnect the operating lever from the central locking solenoid/motor, then withdraw the lock barrel (see illustration). Central locking solenoid/motor removal and refitting is covered in Chapter 13.

12.2 Tailgate lock assembly - Hatchback and Estate models
12.2 Tailgate lock assembly - Hatchback and Estate models

A Lock barrel support bracket B Lock barrel retaining clip C Lock barrel
D Torx screw
E Lock assembly
F Screws

3 Remove the two securing screws and detach the lock barrel support bracket from the tailgate.

4 Where applicable, disconnect the battery negative lead, the earth lead from the tailgate and the Уtailgate ajarФ sensor wiring plug.

Unclip the luggage compartment light switch from the lock assembly, where applicable.

5 Remove the securing screws and withdraw the lock assembly.

Refitting
6 Refitting is a reversal of removal, but do not tighten the lock barrel support bracket screws until the lock barrel has been fitted.

    See also:

    Cylinder head - dismantling and reassembly
    Note: A valve spring compressor will be required during this procedure. New valve stem oil seals should be used on reassembly. 1 Proceed as described in Chapter 2, Part C, noting the following poi ...

    Parking brake
    All vehicles WARNING: Vehicles with an automatic transmission should always be left with the selector lever in position P. Х Press the foot brake pedal firmly. Х Pull the parking brake lever up ...

    Engine compartment overview - 2.0L Duratorq-TDCi (DW) Diesel
    A. Screen washer fluid reservoir*: See Washer fluid check. B. Engine coolant reservoir*: See Engine coolant check. C. Brake and clutch fluid reservoir (right-hand drive)*: See Brake and clutch f ...