Engine/manual gearbox assembly - reconnection and refitting

1 Reverse the procedure described in paragraphs 1 to 33 of Section 7, noting the following points.

2 Before attempting to reconnect the engine to the gearbox, check that the clutch friction disc is centralised.

3 Check that the clutch release arm and bearing are correctly fitted, and lightly grease the input shaft splines.

4 Check that the engine adapter plate is correctly positioned on its locating dowels. If necessary, a cable-tie can be used to temporarily secure the adapter plate in position on the cylinder block, using one of the engine-to-gearbox bolt holes.

5 If shims were fitted between the sump and the gearbox, refit them in their original locations when mating the engine to the gearbox. If the engine has been overhauled, where applicable fit the relevant shims as calculated during engine reassembly.

6 Ensure that the roadwheels and the steering wheel are in the straight-ahead position before reconnecting the lower steering column to the intermediate shaft.

7 Reconnect the clutch cable to the release arm, ensuring that it is routed as noted during removal.

8 Fill the engine with the correct grade and quantity of oil.

9 Check the throttle cable adjustment.

10 Fill the cooling system.

11 Check and if necessary top-up the gearbox oil level.

12 Tighten all fixings to the specified torque, where applicable.

    See also:

    Rear brake shoes - renewal
    Warning: Brake shoes must be renewed on both rear wheels at the same time - never renew the shoes on only one wheel, as uneven braking may result. Also, the dust created by wear of the shoes may ...

    Fuel pump - testing
    1 If the fuel pump is functioning, it should be possible to hear it “buzzing” by listening under the rear of the vehicle when the ignition is switched on. Unless the engine is started, the fuel pu ...

    Pistons and connecting rods - removal and refitting
    1.8 litre (R2A type) Removal 1 With the engine removed from the vehicle, remove the sump and the cylinder head. 2 Check the big-end caps for identification marks and if necessary use a centre-pun ...