Engine/automatic transmission assembly - reconnection and refitting

1 Reverse the procedure described in paragraphs 1 to 25 of Section 8, noting the following points.

2 Check that the engine adapter plate is correctly positioned on its locating dowels. If necessary, a cable-tie can be used to temporarily secure the adapter plate in position on the cylinder block, using one of the engine-to-transmission bolt holes.

3 As the torque converter is only loosely engaged in the transmission, care must be taken to prevent the torque converter from falling out forwards. When the torque converter hub is fully engaged with the fluid pump drivegear in the transmission, distance “A” in illustration 2.24 of Chapter 7B must be as specified. Incorrect installation of the torque converter will result in damage to the transmission.

4 If shims were fitted between the sump and the transmission, refit them in their original locations when mating the engine to the transmission. If the engine has been overhauled, where applicable fit the relevant shims as calculated during engine reassembly.

5 As the engine and transmission are mated together, guide the torque converter studs through the holes in the driveplate. When the engine is positioned flush with the engine adapter plate and the transmission housing, check that the torque converter is free to move axially a small amount before refitting and tightening the engine-to-transmission bolts.

6 Do not tighten the torque converter-todriveplate nuts until the lower engine-totransmission bolts have been fitted and tightened.

7 Ensure that the roadwheels and the steering wheel are in the straight-ahead position before reconnecting the lower steering column to the intermediate shaft.

8 Reconnect the selector rod and check for correct adjustment.

9 Fill the engine with the correct grade and quantity of oil.

10 Check the throttle cable adjustment.

11 Fill the cooling system.

12 Check and if necessary top-up the transmission fluid level.

13 Tighten all fixings to the specified torque, where applicable.

Engine mountings - renewal

Proceed as described in Chapter 2, Part C, but note that on certain models it may be necessary to unbolt the engine mounting brackets from the cylinder block to allow sufficient clearance to remove the mountings.

    See also:

    Underbonnet lamp - removal, refitting and bulb renewal
    1 Disconnect the battery negative lead. Removal and refitting 2 Detach the wiring connector at the left-hand bonnet hinge, and attach a length of string to the end of the wire running from the lam ...

    Fuel system - depressurising
    Warning: The fuel system will remain pressurised after the engine is switched off. Comply with all relevant safety precautions during this operation and refer to the “Safety first!” Section at th ...

    Auxiliary air device - removal and refitting
    K-Jetronic system Removal 1 Disconnect the battery earth lead. 2 Disconnect the wiring multi-plug and the two air hoses from the device which is located beneath the cold start valve (see illustra ...