Engine dismantling, examination, renovation and reassembly - general information

Dismantling
1 Refer to Chapter 2, Part A, Section 18, paragraphs 1 to 8 inclusive.

2 A suitable selection of splined and Torx sockets will be required to remove many of the bolts when dismantling the engine.

3 Before dismantling the main engine components, the following externallymounted ancillary components can be removed, with reference to the relevant Chapters of this Manual and the relevant Sections of this Chapter, where applicable.

Inlet manifold (and carburettor, if applicable) Exhaust manifold
Alternator.

Coolant pump, and thermostat Alternator/coolant pump drivebelt tensioner Distributor cap, HT leads and spark plugs Oil pressure warning lamp switch Crankshaft speed/position sensor Oil filter
Dipstick
Engine mounting brackets (if not already done) Crankcase ventilation pipe and hoses Clutch
Alternator mounting bracket.

Air conditioning compressor mounting bracket (where applicable).

Engine lifting brackets.

Examination and renovation 4 Refer to Chapter 2, Part A, Section 18, but note that the connecting rod bolts should be renewed on reassembly, and when renewing the cylinder head bolts, the latest type bolts with hexagonal heads should always be used.

Reassembly
5 Proceed as described in Chapter 2, Part A, Section 18, noting the following: 6 If they have been removed, new cylinder head bolts (both M11 and M8, of the latest type with hexagonal heads), flywheel bolts, and connecting rod bolts must be used.

    See also:

    Headlamp control
    Turns the lamps off. Turns on the parking lamps, instrument panel lamps, license plate lamps and tail lamps. Turns the headlamps on. Foglamp control (if equipped) Rotate forward to activa ...

    General description
    The body is of welded steel construction available in 3 or 5-door Hatchback, 3 or 5- door Estate, soft-top Cabriolet, or Van configurations. The body is of monocoque construction and is of energy ...

    Hydraulic unit pump and motor (ABS) - removal and refitting
    Note: New sealing washers must be used on the high pressure fluid hose banjo union, and a new O-ring must be used between the accumulator and the hydraulic unit on refitting. Caution: Refer to the ...